Bad injection pump ($2,000 repair quote).
No start but cranking? Check Pin B1 (crank sensor) resistance should be 1.6–2.1 kΩ. If open, the ECU never fires the injectors. Connector C – Outputs & Communications (16P) | Pin | Wire Color | Function | Notes | |------|-------------|---------------------------|------------------------------| | C1 | Black | TC terminal (check engine light) | Switched ground – illuminates when fault exists | | C2 | White | Tachometer output | 12V square wave (diesel tach) | | C3 | Green | AC idle-up request | 12V when AC compressor on | | C5 | Orange | Diagnostic (SIL) | 9600 baud for Toyota scanner | | C6 | Blue/Red | EGR vacuum switching valve (VSV) | 12V control | | C9 | Yellow | Immobilizer communication (if equipped) | Serial data to transponder amp | | C10 | Brown/Red | Fuel heater relay | 12V below 5°C | | C12 | Pink | Idle-up VSV for power steering | 12V at steering load | 1kz ecu pinout
| Model | Stop Solenoid (A14) | TPS Signal (B4) | Crank Sensor (B1) | |-------------------|-------------------|-------------------|---------------------| | KZJ70 Prado | Red/Black | Yellow/Green | Red/Blue | | KZJ90 Prado | Red/White | Yellow/Black | Blue/Black | | Hilux Surf | Red/Black | Green/Yellow | Red/Blue | | Hiace (Van) | Black/Yellow | Yellow/Green | Light Green/Black | Bad injection pump ($2,000 repair quote)
Always confirm pin position by number, not color alone. The pinout’s position is consistent; the wire color is a guide. If you’re building an off-road buggy or custom 4×4, you might need to depin the ECU connectors. If open, the ECU never fires the injectors
Terminal release tool (small flathead), replacement pins (from Toyota or Ballenger Motorsports), and the official Toyota Electrical Wiring Diagram (EWD).
The Toyota 1KZ-TE is one of the most beloved diesel engines ever produced. Found in legendary vehicles like the Land Cruiser Prado (KZJ70, KZJ90), Hilux Surf, and Hiace van, this 3.0-liter turbo-diesel is known for its reliability—until an electrical gremlin appears.
